Permit Number:

Facility Name:

Facility ID:

Working Copy of a Permit in Progress

Permit Writer: Matt Stanfield, TDES

Existing Heaters & Boilers 10 mmBtu/hr at Major HAP Sources burning natural gas or refinery gas and other “gaseous fuels” subject to MACT Subpart DDDDD

B.Facility-Wide Terms and Conditions

  1. All the following facility-wide terms and conditions are federally enforceable with the exception of those listed below which are enforceable under state law only:

a)None

  1. The following emissions units contained in this permit are subject to 40 CFR Part 63, Subpart DDDDD: ADD EMISSIONS UNITS. The complete MACT requirements, including the MACT General Provisions may be accessed via the internet from the Electronic Code of Federal Regulations (e-CFR) website or by contacting the Toledo Division of Environmental Services.

C.Emissions Unit Terms and Conditions

  1. BXXX, for Existing Heaters & Boilers >10 mmBtu/hr at Major Sources burning gaseous fuels (natural gas, refinery fuel gasor other Gas 1 fuels) subject to Boiler MACT, sp DDDDD
  2. NOTE: Those in blue are for other Gas 1 fuels (i.e. landfill gas or other Gas 1 fuels)

Operations, Property and/or Equipment Description:

XXXmmBtu/hr natural gas, refinery fuel gas and landfill gas fired heaters with no control

a)The following emissions unit terms and conditions are federally enforceable with the exception of those listed below which are enforceable under state law only.

(1)None.

b)Applicable Emissions Limitations and/or Control Requirements

(1)The specific operations(s), property, and/or equipment that constitute each emissions unit along with the applicable rules and/or requirements and with the applicable emissions limitations and/or control measures. Emissions from each unit shall not exceed the listed limitations, and the listed control measures shall be specified in narrative form following the table.

Applicable Rules/Requirements / Applicable Emissions Limitations/Control Measures
a. / 40 CFR Part 63,Subpart DDDDD
(40 CFR 63.7480-63.7575)
[In accordance with 40 CFR63.7500(a)(1), this emissions unit is an existing heaterdesigned to burn natural gas, refinery fuel gas and other Gas 1 Fuels (i.e., landfill gas)located at a major source of hazardous air pollutants and subject to the work practice standardspecified in this section.] / This rule does not establish an emission limitation or control measure. The rule requires work practice standards that are specified in Table 3 of this subpart..
b. / 40 CFR 63.1-15
(40 CFR 63.7565) / Table 10 to Subpart DDDDD of 40 CFR Part 63–Applicability of General Provisions to Subpart DDDDD shows which parts of the General Provisions in 40 CFR 63.1-15 apply.

(2)Additional Terms and Conditions

  1. None

c)Operational Restrictions

(1)The permittee shall comply with the applicable restrictions required under 40 CFR Part 63, Subpart DDDDD, including the following sections:

63.7500(a)(3) / operate in a manner consistent with good air pollution control practice

d)Monitoring and/or Recordkeeping Requirements

(1)The permittee shall comply with the applicable monitoring and record keeping requirements required under 40 CFR Part 63, Subpart DDDDD, including the following sections:

63.7500(a)(1) / Table 3 requires an annual tune-up and one-time energy assessment
63.7515(e) / when annual tune-upis required
63.7521(f) / Qualifications for other gas 1 fuels, conduct a fuel specification analysis
63.7521(g) / Develop and submit a site-specific fuel analysis plan for other gas 1 fuels
63.7521(h) / Fuel sampling for other gas 1 fuels
63.7521(i) / Determining concentration of mercury and hydrogen sulfide in other gas 1 fuels
63.7530(g) / Initial fuel specifications for other gas 1 fuels
63.7540(a)(10), (a)(12) / annual tune-up requirements
63.7540(c) / Additional monthly fuel specification testing of other gas 1 fuels if a signed certification is not submitted.
63.7555(a) / record keeping requirements
63.7555(g) / Record keeping requirements for other gas 1 fuels
63.7555(h) / records of alternative fuel usage
63.7560(a), (b) and (c) / recordsretention

e)Reporting Requirements

(1)The permittee shall submit semiannual reports and such other notifications and reports via the Air Services component of the Ohio EPA's eBusiness Center as are required pursuant to 40 CFR Part 63 Subpart DDDDD, per the following sections:

63.7495(d) / meet the notification requirements in 63.7545 and Subpart A
63.7530(e) / include energy audit certification with Notification of Compliance Status
63.7545(a) / General Provisions notifications
63.7545(b) / Initial Notification
63.7545(f) / notification of alternative fuel use
63.7545(h) / reporting fuel switch to different category
63.7550(a), (b) / compliance report
63.7550(c)(1) - (3),(8)and (12) / compliance report content
63.7550(f) / semi-annual deviation report

f)Testing Requirements

(1)None

g)Miscellaneous Requirements

(1)None.

Page 1 of 6