XJ-S AFTERMARKET PARTS
XJS Aftermarket Parts - Introduction 5
Air Conditioning Parts 7
A/C Clutch & Parts A-6 Compressor 7
A/C Clutch Parts Sanden / Sankyo Compressor (’92 - ’96 models?) 8
A/C Clutch Parts York Compressor (I don’t think any XJS used York) 8
A/C Compressor & Parts - A-6 Compressor 8
A/C Compressor & Parts - Sanden SD709 – 7494 10
A/C Compressor Cutoff Switch 10
A/C Condenser 10
A/C Control Switch 11
A/C Evaporator Core 11
A/C Evaporator Thermo Unit 11
A/C Expansion Valve 11
A/C Hoses 11
A/C Receiver Dryer XJS !976-1996 12
A/C Seals and Gaskets 12
A/C Superheat Switch – A6 Compressor 12
A/C Thermal Limiter Fuse 12
Air Intake Sensor Connector 13
Air Injection Check Valve (Jaguar # C34017) All XJS with V12 13
Air Pump (Uses standard GM pump) 13
Alternator 13
Anti-Sway Bars 16
Auxiliary Air Valve Hose 16
Banjo Bolt Copper Washers 16
Battery Cables - All models 16
Belts 17
Brake - ABS Accumulator 18
Brake - ABS Control Module 19
Brake - ABS Hydraulic Unit (Modulator Valve)(Remanufactured) 19
Brake - ABS Pump & Motor Assembly (Remanufactured) 19
Brake Bleeder Screw 19
Brake Booster (Power) 19
Calipers - Front and Rear 20
Brake Caliper Hardware- 25
Brake Master Cylinder 27
Brake Master Cylinder Reservoir Hose 28
Brake Rotors 28
Rear – TWR Style 30
Brake Disc Hardware Kit 30
Brake Rotor Mounting Nuts (Rear) 31
Brake Dust Shields 31
Brake Hoses 31
Brake Pads 32
Brake Pads – Parking Brake 32
Brake Pad Shim Kit 32
Brake Wear Sensor 33
Catalytic Converter 33
Clutch Hydraulics - 4.0L Six 34
Clutch Pilot Tool - 4.0L Six 34
Coil 34
Convertible Top (Hood) 35
Copper Washers 35
Crankshaft Seal 35
Delay Timers 35
Differential Bearings 36
Differential Pinion Seal 36
Differential Pinion Sleeve 36
Distributor Cap 36
Distributor – Ignition Reluctor 38
Distributor Pickup 38
Distributor Rotor 39
Distributor “Thingy” 41
Door Hinge Pins & Bushings 41
ECU (see “Fuel Injection ECU”) 41
Electronic Ignition Module 41
Engine - Connecting Rod Bearings 42
Engine - Crankshaft Rear Oil Seal 42
Engine - Crankshaft Thrust Washer 42
Engine - Long Block 43
Engine - Main Bearings 43
Engine Mount - See Motor Mount 43
Exhaust Check Valve (w/ AIR pump) 43
Exhaust Chrome Tips - V12 43
Exhaust Hangers 43
Exhaust Pipe 43
Exhaust Systems 44
Fan Clutch 44
Filters 45
Air 45
Fuel 46
Oil 47
Automatic Transmission 48
Flashers 49
Fuel Filler Cap 49
Fuel Injectors 49
Fuel Injector Cold Start Valve 50
Fuel Injection ECU 51
Fuel Injection Harness Connectors 52
Fuel Injection Pressure Regulator 53
Fuel Injection Relay 54
Fuel Injection Thermo-Time Switch 54
Fuel Injector Seals 54
Fuel Pump 54
Fuel Tank Sender Float 56
Fulcrum Bearings (Rear End) 56
Gaskets 56
Cam Cover - 4.0L Six 56
Cam Cover - V12 56
Conversion Lower Set (whatever that means) V12 56
Exhaust Flange 56
Exhaust - Center Muffler Gasket 56
Exhaust - Front Muffler to Intermediate Pipes V12 56
Exhaust - Intermediate Muffler to Over-Axle Pipe V12 57
Exhaust Manifold 57
Head Gasket Set - V12 Pre HE 57
Head Gasket Set - V12 HE 57
Intake Manifold V12 57
Oil Pan Set V12 57
Thermostat Gasket 57
Transmission Extension Housing to Case- Turbo 400 57
Transmission Oil Pan Gasket 58
Transmission Pump Cover to Case- Turbo 400 58
Glass NAGS Numbers 58
Grease Caps 59
Headlamp Assembly 59
Heater Valve 59
Hood Struts 59
Horns 60
Idler Pulley 60
Ignition Amplifier 60
Ignition Module 61
Inertia Switch – Fuel Pump 61
Jockey Pulley (See Idler Pulley) 61
Jaguar Sport parts 61
Microswitches (Kickdown, Wide-Open-Throttle, etc) 61
Mirror Replacement Glass 61
Motor Mount 61
Muffler 61
Oxygen Sensors 62
Oil Pressure Sending Unit 64
PCV Valve 65
Piston Rings 66
Power Steering Pump 4.0L Six 66
Power Steering Pump-V12 (GM Saginaw Unit) 66
Power Steering Pump Kits 66
Drive Shaft Seal 66
Rebuild kit 66
Pump Seal Kit 66
Power Steering Hoses- 67
Power Window Motor (Used) 68
Power Window Motor Gears 68
Rack and Pinion Assembly (Rebuilt) 68
Rack and Pinion Bellows Kit 70
Rack Mount Bushings (presumably standard materials) 70
Rack Mount Bushing Kit (Polyurethane) 70
Radiator Cap 70
Radiator Hoses 70
Rear Axle Pinion Bearings 71
Rear End Wishbone Bearings 71
Rear Subframe Mount Bushings 71
Relays 71
Rochester Valve (Fuel Vent System) 72
Seat Covers 72
Sensor – Ambient Air 72
Sensor – Coolant Level 72
Sensor – Crankshaft Position 72
Shock Absorbers 73
Shock Absorber Upper Bushings (Front) 73
Smog Pump - See “Air Pump” 73
Spark Plug Wire Set 73
Spoiler – Front 75
Starter 75
Starter Brushes 77
Starter Drive 78
Starter Solenoid 78
Starter Relay 78
Steering Rack Bushings – See Rack Mount Bushings 79
Suspension - Ball Joints 79
Suspension - Lower Control Arm Bushing set 80
Sway Bar Assembly - All XJS 80
Sway Bar Bushings 80
Sway Bar Link Kit 80
Temperature Gauge Sending Unit 80
Temperature Sensor Connector 81
Thermal Limiter Switch (Fuse) 81
Thermo-Fan Switch 81
Thermostats 82
Thermostat Gaskets 84
Tie Rod End 84
Timing Cover Seal V12 85
Transmission Accumulator Piston (new style - aluminium) 85
Transmission Accumulator Piston Seal (oil ring) 85
Transmission Bands 85
Transmission Bushings 85
Transmission Clutch Plates 86
Transmission Extension Housing Oil Seal 88
Transmission Front Pump Oil Seal 89
Transmission Mount Parts 89
Transmission Overhaul Kit 90
Transmission Shift Shaft Seal 90
Transmission Seals – Other 91
Transmission Sprag Assembly-Spring/ROL Kit 91
Transmission Springs 92
Transmission Vacuum Modulator 92
Transmission Valve Body Gasket 93
Transmission Washers GM TH400 93
Turn Signal Flasher Unit 93
U-Joints - All Models 93
Valve Keepers 94
Valve Stem Seals 94
Voltage Regulator - V12 94
Water Pump (Rebuilt) 95
Water Pump (New) 95
Wheel Bearings 97
Wheel Bearing Seals 99
Windshield Washer Pump 101
Windshield Wiper Arm & Blade assembly 101
Windshield Wiper Blade 101
Wiring Harnesses 102
Wood Trim 103
Other Suppliers – The following have websites that suggest they can supply Jaguar products, but do not list part numbers: 103
Version 08/31/00
XJS Aftermarket Parts - Introduction
Notes:
The purpose of this document is to identify vendors of aftermarket parts by the part type. You will notice that different vendors often show different ranges of years that a particular part will fit. Vendors’ catalogs are frequently in error as to model year application. It would be useful to know what years will fit your particular car, in case you see a vendor who has the part, but doesn’t include your car in the range of years that the part fits. In addition, some of the Beck Arnley information came from a catalog that listed parts for 1985 forward. 1984 and prior years were in a separate catalog. Do not assume that parts labeled 85-91 will not fit earlier years. In addition, do not assume that Beck Arnley does not offer parts for pre-HE models. Check with your vendor, and always double check part numbers, as I may have made errors in copying them down
Caution: Different manufacturer's catalogs offer conflicting information regarding the year in which a change was made (e.g. A/C expansion valves). If you come across this, be sure to bring in your old part when buying the new one.
In addition, sometimes the manufacturers catalogs are FLAT OUT WRONG. For example, the front wheel inner grease seal changed with the introduction of ABS, yet virtually every catalog lists the pre-ABS seal for ABS models.
Rebuilt starters and alternators are widely available. Lucas has purchased many regional rebuilders, and lists rebuilt units for Jaguars. No doubt there are many other rebuilders who are not listed here.
Although not listed in Bosch catalogs, a Bosch dealer assured me that a Bosch supplier could supply any Bosch part by number. This would apply to power window motors, relays, fuel injection and ABS parts.
Certain common parts such as spark plugs or brake pads are not listed. Virtually any supplier can provide a listing for these items.
I have no information on how to locate a retail vendor of most of the brands listed here. For mail order, try www.carparts.com, My main intent is to make the reader aware of the types of parts that are likely to be available from the aftermarket. In the course of compiling this data, it became clear that many vendors are repackaging parts that have been obtained from another source. In many cases, both the manufacturer and the re-seller use the same part number.
The vendors listed here are primarily U.S. based. This is mainly due to the fact that those are the vendors whose information was readily accessible to me. If someone can point me to catalog listings for UK and Australian suppliers, I will include that information in later versions.
At this point, this listing deals only with non-original, aftermarket parts that are cataloged as Jaguar parts. There are sometimes parts that fit other cars, which are either a direct replacement, or can be made to fit. There are also many sources for Jaguar original parts other than Jaguar dealers (e.g. Special Interest Car Parts, Welsh Enterprises, Coventry West, H.D. Rogers, www.jagbits.com, etc). Both of these categories are covered in Kirby Palm’s Experience in a Book.
Disclaimer: You are advised to sanity check the data yourself, and inspect the part carefully before installing (always good advice). The usual disclaimers apply, that is, you take the responsibility for the use of this information or any consequences from usage of these parts. Use your own judgment. If you do not want to use such judgment and be prepared for anomalies, get the exact original part from the dealer. Or, have the dealer or qualified mechanic do the entire repair for you.
If you discover bad data here, please notify me.
Part Number
Air Conditioning Parts
A/C Clutch & Parts A-6 Compressor
AC Delco
Pulley Bearing 15-2802 or 6557684
Clutch coil 15-45
Clutch Assembly (Hub & Coil) 15-41
Clutch Pulley, w/ bearing 15-224
Hub Snap Ring 15-48
Hub Spacer 15-49
Shaft Key 15-46
Shaft Nut 15-2129
BCA/Bower
Clutch Bearing 907257
Everco
Clutch- remanufactured A8414
Clutch coil A8415
Four Seasons (Division of Standard Motor Parts)
Bearing 25203
Harness Connector-Extender 37209
Harness Connector – Repair 37201
Hub Snap Ring 24175
Hub Spacer 24173
Installation Kit 24169
Shaft Key 24176
Shaft Nut 24172
Snap Ring - Pulley Retainer 24184
Remanufactured Clutch 48284
Conduct-tite
Coil connector with diode 85143
BOS / L&S / Perfect Circle
Bearing 907257
Murray
Clutch - w/o coil- 4.75" diameter pulley 261250
Clutch - w/o coil- 4.75" diameter pulley 261264
Clutch - w/o coil- 5.625" diameter pulley 261239
Clutch coil for all of above 261260
Coil connector with diode 207496
Coil connector w/out diode 207402
NAPA
Coil 261260
Hub & Shoe 261255
Remanufactured Clutch w/coil 261250
A/C Clutch Parts Sanden / Sankyo Compressor (’92 - ’96 models?)
BCA/Bower
Clutch Bearing 5001KFF
Four Seasons (Division of Standard Motor Parts)
SD-5 Bearing 25267
“Clutch” Bearing – SD510 25207
Coil - New 47800
Installation Kit 24168
Shaft Key – SD510 24193
DS7 Shaft Seal Kit - SD709 24031
DS5 Shaft Seal Kit - SD510 Not Stocked
A/C Clutch Parts York Compressor (I don’t think any XJS used York)
A/C Delco
Clutch – Mini 206 with 6” pulley 15-4252
Clutch – Model 209/210 with 7” pulley 15-4148
Clutch – Model 209/210 with 6” pulley 15-452
Four Seasons (Division of Standard Motor Parts)
Bearing 25204
Brush 35704
Coil - Pitts 47808
Coil - Warner 47794
Shaft Key 24171
Murray
Clutch - w/o coil- 6.0" diameter pulley 274224
Clutch - w/o coil- 7.0" diameter pulley 274223
Clutch coil - 6.0" pulley 274221
Clutch coil - 7.0" pulley 274222
A/C Compressor & Parts - A-6 Compressor
High Pressure Switch replaced Superheat Switch at Chassis # 139052
AC Delco
New Compressor, with superheat switch 15-2227
New Compressor w/out superheat switch 15-2224
Remanufactured compressor w/ superheat switch 15-2143
Remanufactured compressor w/out superheat switch 15-2141
Suction Cross Over Cover - w/A6 Compr. 15-2229
Cylinder & Shaft Assembly- w/A6 Compr.;
Req. Use w/{15-2191};{15-234};{15-237};{15-290} 15-219
Cylinder & Shaft Assembly Kit w/A6 Compr.
Req. Use w/{15-219} 15-2191
Cylinder & Shaft Assembly Kit] w/A6 Compr.
Req. Use w/{15-219} 15-234
Cylinder & Shaft Assembly Kit w/A6 Compr.
Req. Use w/{15-219} 15-237
Cylinder & Shaft Assembly Kit w/A6 Compr.
Req. Use w/{15-219} 15-290
Compressor Head - Rr.; Non Superheat; w/A6 Compr. 15-2182
Compressor Head - Frt.; w/A6 Compr. 15-229
Head Locator Pin Kit - A6 Compr. 15-290
[Nut Kit] Shell & Shaft;- A6 Compr. 15-234
Oil Pump Kit - A6 Compr. 15-236
Retainer Ring Kit - A6 Compr. 15-235
Suction Screen - A6 Compr. 15-231
Oil Drain Screw - A6 Compr. 15-2140
Oil Inlet Tube - A6 Compr 15-230
Reed Suction Valve Frt. & Rr. - A6 Compr. 15-228
Pressure Relief Valve] w/O-Ring; A6 Compr.; 15-5415 or 15-511
Everco
Remanufacturerd compressor w/ clutch A8604
Four Seasons (Division of Standard Motor Parts)
aka Big A, aka Factory Air, aka Parts Master
Compressor Mounting Bolts – Metric (R4) 12696
Compressor Mounting Bolts - American 12697
Manifold Hold Down Bolt Kit - Metric 12694
Manifold Hold Down Bolts - American 12691
Relief Valve 35753
Shaft Seal Kit – Ceramic 24016
Shaft Seal kit - Steel 24015
Snap Ring - Pressure Switch 24185
Snap Ring - Shaft Seal 24183
Remanufactured compressor w/ superheat switch w/ clutch 57098
Remanufactured Compressor w/o superheat switch w/clutch 57096
Murray
Remanufactured compressor w/ clutch 251129
NAPA
Remanufactured compressor w/ superheat switch w/clutch 251101
Remanufactured Compressor w/out superheat switch w/clutch 251123
VACP (Vehicle Air Conditioning Parts) http://www.vacp.com/catpage.html
Remanufactured comp. w/ superheat switch w/ clutch Non metric V3019
Remanufactured comp. w/ superheat switch w/ clutch Metric V3145
Remanufactured comp. w/ hi press switch w/ clutch Metric V3020
A/C Compressor & Parts - Sanden SD709 – 7494
VACP (Vehicle Air Conditioning Parts) http://www.vacp.com/catpage.html
Compressor - 4.0L Six from Chassis # 139052 – 190527 V3043
Four Seasons
Remanufactured compressor w/ clutch 57586
A/C Compressor Cutoff Switch
Everco
A6 Pressure Relief Valve A7247
Truemark
A6 70 - 79 Axial Compressor with Super Heat 35755
A6 81 - 92 Axial Compressor with High Pressure 35756
VACP (Vehicle Air Conditioning Parts) http://www.vacp.com/catpage.html
4.0L Six - Low Pressure Cutout Switch for rear head V6040
A/C Condenser
VACP (Vehicle Air Conditioning Parts) http://www.vacp.com/catpage.html
5.3L V12 from VIN 148782 – 188104 (Jag#CBC8540) V1047
6.0L V12 from VIN 190528 on (Jag#MHD7390AA) V1269
4.0L Six from VIN 190528 on (Jag#MHD7390BA) V1268
A/C Control Switch
Texas Air Auto Parts
75 – 91 Lever W/O Resistor; W/5 Terminals 22-716
75 – 91 4 Position Resistor; W/3 Terminals 22-707
75 – 91 Rotary W/O Resistor; W/5 Terminals 22-706
A/C Evaporator Core
(According to Welsh Enterprises, the same evaporator (AEU-1191-A)fits 1982-1988 (Delanair MK II) and Series 3 XJ6. JLM-1197 fits XJS 1989-1992 (Delanair MK III). AFAIK, Delaniar MKIII started with 1988 models. )
Car Care Parts
"All except 1994 (and later?) 6.0L" 14-9308 ? 14-9303