CHASSIS
2016Ford E-350Super Duty Dual Rear Wheel Cut-Away
Wheelbase: / 138”GVW Rating: / 11,500 lbs.
GAWR (Front): / 5,000 lbs.
Axle, Front: / 5,000 lbs.
Axle, Rear: / 8,500 lbs.
Axle Ratio: / 4.10 Limited Slip
Brakes, Service: / Dual Piston Caliper, Anti-lock
with Hydro-Boost
Electrical – Alternator: / 225 Amp Extra Heavy Duty
Engine/HP/Torque: / 6.8L Triton® V-10 Gasoline
305 HP @ 4,250 RPM/420 lb.-ft. @ 3,250 RPM
Fuel Tank: / 40 Gallon, Aft of Axle
Shock Absorbers: / Heavy Duty Gas-Type – Front and Rear
Springs, Front Coil: / 5,000 lbs.
Springs, Rear Leaf: / 8,500 lbs.
Stabilizer Bar, Front: / .91” Diameter
Stabilizer Bar, Rear: / 1.125” Diameter
Steering: / Gear Assembly Power Steering
Tires: / (6) LT225/75Rx16E BSW All-Season
(1) Spare Tire
Transmission: / 5-speed TorqShift® Overdrive
In-Tank Oil Cooler
Aux. Transmission Oil Cooler
Wheels: / (6) 4-Hole Disc, 16” x 6.0” Steel – Painted White
47A Ambulance Prep Pkg.: / Auxiliary HVAC Connector Package
Manual-telescoping Trailer Tow Mirrors
Trim Level: / XL
Other Features: / Tilt Steering Wheel
Cruise Control
High-Back Captain’s Chairs
Mud Flaps: / Black, Anti-Sail
PATIENT MODULE
Module: 146" long x 90" wide
Headroom:68" interior
Module Exterior Compartment Configuration
Location / Measurements (Interior) / Use / CuFtCurb Side Front (C1) / 42 ¾”h x 17 ½” w (opening) / ALS access / ------
Curb Side Rear (C3) / 33” h x 38” w x 15 ¼” d / General / 11.07
Street Side Front (S1) / 60 ¾” h x 17 ¾” w x 15” d / Oxygen / 9.36
Street Side Intermediate (S2) / 38 ½” h x 31 ¼” w x 15” d / General / 10.44
Street Side Rear (S3) / 80 ¼” h x 25” w x 8” d / Spineboards / 9.29
Bumper:Rear with center flip-up non-skid gator grip, under body skids with integral tow eyes.
Doors:Seamless doors with extruded jambs.
Door Handles:Tri-Markpaddle style handles on all on all patient entry doors and exterior compartment doors. Patient entry doors to have emergency releases for rotary door locks.
Door Holders:Rear entry – Cast Grabber, 5.5”
Side entry – Gas Strut
Compartments – Gas Strut
Door Panels:Stainless steel, upper and lower panels.
Reflective red/white chevrons on center portion of each door panel.
Fender Flare:Bright finish.
Insulation:Fiberglas, battinsulation in patient compartment and solid block foam in doors.
Kick Panel:Aluminum diamondplate.
Shelves:(1) Fixed in street side intermediate compartment S2
(1)Adjustable in curb side front ALS compartment C1
Skirt Rails:Lower, heavy duty rubber.
Stone Guards:All four corners, diamondplate.
Windows:Enlarged curb side & rear doors, uppers only,
Curbside - sliding, privacy tint
Rear - fixed, privacy tint
ELECTRICAL
Antenna Cables:(1) routed from ceiling to behind front passenger seat.
Back-Up Alarm:Mounted underneath rear of body with automatic reset switch.
Batteries:(1) OEM battery under hood
(1) OEM on slide tray in RF lower compartment
Battery system activated through OEM ignition switch.
Battery Charger:Progressive Dynamics PD9130 battery charger/conditioner. Wired to shoreline inlet.
Circuit Board:Kinequip relay-based circuits, with manual resetting fuses. All electrical wires are printed every 8” with wire name/code.
Exhaust Vent:Marine style blower with adjustable intake vent on left wall cabinet. Switch in rear Action Area.
Front Console:Doghouse mounted with emergency and patient compartment master switches, door-ajar lights, all function switches and battery indicator lights. Switches are full size black Euro-style switches with LED indicators.
Heat/Cool System:Combination A/C and heater mounted above RF ALS cabinet. Thermostat in Action Area.
Inverter:Pre-wire only.
Lighting, Compartment:(1) per compartment with automatic door switch.
Lighting, DOT:Incandescent front and rear FMVSS clearance lights.
Trucklite rectangular incandescent Stop-Tail-Turn-Back Up lights with rubber grommet mounting.
Dietz license plate holder with light. Mounted on street side rear.
Light, Action AreaIncandescent light with integral switch mounted in ceiling of Action Area.
Light, Electrical:Incandescent light mounted within the electrical circuit board cabinet and wired battery hot to provide light when working within the cabinet.
Lighting, Interior Dome:(6) Weldon 8” round halogen hi-low. (3) lights over primary patient and (2) lights over squad bench.
Light, Step Well(1) Trucklite 2” round incandescent light.
Lighting, Non-Emergency:
Loading Lights:(4) Whelen Opti-scene, 97H, halogen, (2) each side
Rear Scene Lights: (2) Whelen Opti.-scene, 97H, halogen, on rear wired to rear doors, and
Reverse gear.
Shoreline Inlet: 15 Amp, GFI protected circuit, inlet mounted above street side intermediate compartment.
Volt Meter:Smart Voltmeter with low voltage alarm and warning light installed on front console.
110 Volt Outlets:(1) outlet mounted in Action Area and (1) outlet mounted in front ALS cabinet. Wired to shoreline and inverter pre-wire.
12 Volt Outlets:Cigar lighter style, (1) in Action Area, (1) in front ALS cabinet.
Wired to 12 Amp circuit, ignition hot.
12 Volt Power Source:(1) 20 Amp ignition/shoreline hot. Circuit routed to behind Action Area and behind driver’s seat.
EMERGENCY WARNING SYSTEMS
Body Lights:(12) Whelen 9H, halogen red flashing lights. Mounted:
(2) Front upper outer corners
(2) Front between outer warning lights and center clear light.
(2) Each side
(2) Rear, upper outer corners
(2) Rear, mid body to show through rear door windows.
(1)Whelen 9H, halogen clear flashing light. Mounted front center of modular body.
(1)Whelen 9H, halogen amber flashing light. Mounted above rear patient compartment entry doors.
Grille Lights: (2) Whelen LIN3 LED red flashing lights mounted in OEM grille.
Intersection Lights: (2) Whelen 7HLED flashing lights, with flange, red lens.
Siren:Whelen WS-295HFSA1 located in front switch console. With microphone.
Siren Speakers:(2) 110 watt, mounted behind front grille.
OXYGEN / SUCTION SYSTEM
Oxygen Bracket:Versatile “M” or “H” Oxygen Bottle rack with (3) ratchet style cylinder straps. Located in street side forward compartment (S1).
Oxygen Outlets:(1) Ohio style in action area.(1) Ohio style at head of squad bench.
Oxygen Regulator:(1) 50 PSI pre-set oxygen regulator. Ship loose.
Suction Container: Sscor 22000 regulator / holder for disposable canister.
Suction Outlet:Ohio style vacuum port in action area.
Suction Pump:12V electric vacuum pump.
Patient Compartment Interior
Patient Compartment Cabinet Configuration
Location / Measurements (Interior) / CuFtLeft Wall – Upper Rear / 14 ¼” x 24” x 7” / 1.39
Left Wall – Center Upper / 14 ¼” x 45” x 16” / 5.94
Left Wall – Middle Rear / 18 ¾” x 24 ½” x 16 / 4.25
Left Wall – Middle Forward / 18 ¾” x 24 ½” x 16 / 4.25
Left Wall – Lower Rear / 18 ¾” x 24 ½” x 16 / 4.25
Left Wall – Lower Forward / 18 ¾” x 24 ½” x 16 / 4.25
Left Wall – Upper Forward / 14 ¼” x 45” x 13 ½” / 4.70
Front Wall - ALS / 44 ¾” x 31 ½” x 18 ¼” / 14.89
Squad Bench / 6 ¾” x 29 ¼” x 16” / 1.83
Construction:¾” special boat plywood with waterproof glue covered with high
impact laminated plastic. Cabinets constructed with glue-in-place wooden dowels, 3mm edge banding on all exposed edges.
Aisle Space:49” between squad bench and base wall cabinet.
ALS Access:ALS front cabinet with inside/outside access through curb side front compartment.
Attendant Seat:High back captain's chair with 3-point seat belt.
Biohazard-Sharps:Biohazard and sharps container at head of squad bench.
Bulkhead:Sliding partition door with sliding Lexan viewing window.
Cot Fastener:Ferno Stat Track, single position, ST, 86” Change Notice 8 compliant.
Floor Covering:Johnsonite Optima Sidewalk #866 vinyl.
Grab Handles:Stainless steel handicapped style grab handles installed on each patient compartment entry door.
Grab Rail:95" overhead, 1" diameter handicap style rounded ends. Stainless steel.
Headliner: Flat headliner with access to electrical wiring.
I.V. Holders:(1) Clip style.
Lexan: All sliding Lexan is 3/16" thick, gray. All sliding doors have full height extruded aluminum pull handles.
Non-Skid Strips:Black non-skid safety strips installed at side entry and rear entry doors.
Seat Belts:6-point seat belt harness for seating positions one and two on squad bench.
Straps:(1) Street side exterior compartment (S3) for spineboards.
(1)Street side interior rear for stair chair.
Squad Bench:Split lid with storage under front half. 30 lb. gas strut hold open device for cushion to allow access to storage area within bench.
PAINT, DECALS, LETTERING
Labels: (2) "No Smoking - Oxygen Equipped"
(2) "Use of Seat Belt Required"
Paint:Main body, FordOEMwhite
Sikkens FA91:YZ
1