After Market Utility Power Equipment Brokerage
Mailto:
Turbine URL:
Reciprocating URL:
GTG_1576RC_PG6561.doc
1 x Rebuilt GE PG6561B 40Mw 60Hz Natural Gas CoGen Power Plant w/Vogt HRSG
Price: $5,775,000 Where Is
Location:New Jersey
Gas Turbine: 40000 Kw General Electric, Model Pg6561b, Natural Gas Fuel, Multi-Stage, Axial Flow Compressor, Compressor Speed, 5133 Rpm. The Gas Turbine Package Consisting Of:
PG6561b Model Gas Turbine
The Gas Turbine Compartment:
- Multi-Stage Axial Flow Compressor
- Modulated Inlet Guide Vanes
- Ten (10) Chambers Combustion System
- On Base Natural Gas Combustion System With DLN Combustors.
- Ignition System With Spark Plugs And U.V. Flame Detectors
- Borescope Openings For Maintenance Inspection
- Vibration Sensors Selsmic Type For Protection
- Thermocouples For Measuring Exhaust Temperature
- Thermocouples On Bearing Drains
- Inlet And Exhaust Plenums
- Fire Detection By Thermic Detectors And Protection System
- Gas Leak Detection
- Off-Line Compressor Wet Washing System
The Accessory Compartment:
- Auxiliary Gearbox
- Flexible Gear (Oil Filled) Auxiliary Coupling
Lubricating Oil System With:
- Duplex Oil Filters, Single Oil To Water Heat Exchanger,
- Shaft Driven Main Oil Pump, Full Flow Ac Motor Driven
- Auxiliary Oil Pump, Safe Shutdown Flow Dc Motor Driven
- Emergency Oil Pump, Oil Reservoir
Starting And Cool Down System With:
- 440 Volt Ac Motor, Hydraulic Torque Converter,
- DC Electro-Hydraulic Rotor Turning Device
Hydraulic Oil System With:
- Shaft Driven Hydraulic Oil Pump
Gas Fuel System With:
- Combined Stop And Speed Ratio Control Valve Assembly
- Gauges Board Panel
- Fire Detection By Thermic Detectors And Protection System
On-Base Standard Outdoor Type Enclosure
Rigid Type Load Coupling
Calculation Conditions:
Turbine Type 6561b
Cycle Cogeneration
Combustion System DLN
Fuel Lhv Normal Gas 20767 Btu/Lb
Inlet Pressure Drop 100 Mmh2o
Heat Rate 10870 Btu/Kw Base
Exhaust Pressure Drop 376 Mmh2o
Atmospheric Pressure 1010 Mbar
Grid Frequency 60 Hz
Power Factor 0.85
Compressor Speed 5133 Rpm
Generator:
Rating:40375 Kw
Phase/Frequency:3/60 Hz
Voltage:13.8 KV
Poles:2
Synchronous:Yes
PF:0.85 Pf
KVA:47,500 Kva
Stator Winding:Class F Insulation.
The Generator Package Consisting Of:
- The Load Gear Compartment:
- Load Gearbox
- Ventilation System (Single Fan)
- Lubrication System (Common With Gas Turbine)
- Seismic Type Vibration Sensors For Protection
- Thermocouples In Bearing Oil Output Drains
The Generator Compartment:
13.8 Kv, 60 Hz, 2 Poles, Synchronous Generator Including:
Stator Winding Class F Insulation, Forged Steel Rotor With
Class F Insulation Winding, Lubrication System (Common With
Gas Turbine), Thermocouples In Bearing Oil Outlet Drains,
Heating System, Open-Air Ventilation System With 2-Stage Air
Filter, Thermocouples In Ventilation Air Circuit
* Brushless Type Exciter With Ex2000 Shunt Excitation
Medium Voltage Frame With: Generator Outgoing Terminals,
Vts And Cts For Measurement, Protection And Regulation
Generator Star Point Formation And Grounding Through A
Resistor, Lighting Arrestors And Capacitors, Excitation
Transformer.
* The Gas Turbine Generator Control Equipment:
Located Into An Air Conditioned Turbine Control Compartment
Designed For Outdoor Installation And Consisting Of:
Speedtronic Mark V Turbine Control Panel, Speedtronic Mark V
Operator Interface Panel, Generator Control And Protection
Panel, Generator Excitation And Regulation Panel, Unit Ac/Dc
Motor Control Center, Unit Ac/Dc Subdistribution Panel,
125 Volt Dc Unit Battery With One (1) Battery Charger, Unit
Fire Detection And Protection Panel, Marshalling Panel.
* Off-Base Unit Mechanical Auxiliaries:
Inlet Air System, Vertical Exhaust System, Gas Fuel Off-Base
System, Distillate Off-Base System, Off-Base Cooling Loop For
Gas Turbine And Generator Cooling System, Fire Protection For
Gas Turbine Generator, One (1) Oil Mist Eliminator With Single
Extraction Fan, One (1) Gas Compartment Ventilation Unit.
Vogt HRSG 230 Psig/385 Deg F, 334,500 Lbs/Hr With Duct Burner
History:
Year Built: 1999
Year Shutdown: Still Connected
Life Time Hours: 57,463
Life Time Starts: 64 (Used As Base Load)
Last Inspection: 2004
Hours Run Since Inspection: 7,400
Scope Of Supply:
Complete Gas Turbine Generator, HRSG, All HRSG Auxiliaries, Turbine Control
System, Generator Breaker And Control System, Air Inlet, All Available
Drawings,
Manuals And Tools.